关闭选单

液态铝电解电容器-贴片型(温度135℃)

线上寿命测算
Value(uF) V(rated) Manufacturer Series Dimension case Freq Coeff. F Rated temp Rated Life Rated ripple current Actual ripple current Ambient temp Apply Ix Temp Rise LIFE EXPECTED
D(mm) L(mm) To(deg C) Lr(Hours) Io(mArms) Ix(mArms) Tx(deg C) △Tx(deg C) Lx(Hours) Lx(Years)
{{ countData[12].value || '-' }} {{ countData[13].value || '-' }} {{ countData[14].value || '-' }}
Value(uF) V(rated) Manufacturer Series Dimension case Freq Coeff. F Rated temp Rated Life Rated ripple current Actual ripple current Ambient temp Apply Ix Temp Rise LIFE EXPECTED
D(mm) L(mm) To(deg C) Lr(Hours) Io(mArms) Ix(mArms) Tx(deg C) △Tx(deg C) Lx(Hours) Lx(Years)
{{ countData[15].value || '-' }} {{ countData[16].value || '-' }} {{ countData[17].value || '-' }}
Value(uF) V(rated) Manufacturer Series Dimension case Freq Coeff. F Rated temp Rated Life Rated ripple current Actual ripple current Ambient temp Apply Ix Temp Rise LIFE EXPECTED
D(mm) L(mm) To(deg C) Lr(Hours) Io(mArms) Ix(mArms) Tx(deg C) △Tx(deg C) Lx(Hours) Lx(Years)
{{ countData[18].value || '-' }} {{ countData[19].value || '-' }} {{ countData[20].value || '-' }}
计算公式
1. Ambient Temp : 125℃<Tx≦135℃
L_x = L_r \times 1.5^{\frac{(T_o-T_x)}{10}} \times 2^{\frac{-\triangle T_x}{5}} \\ where \triangle Tx=\triangle T₀(Ix / I₀)²

2. Ambient Temp : 105℃<Tx≦125℃
L_x = L_r \times 1.5 \times 1.7^{\frac{(125-T_x)}{10}} \times 2^{\frac{-\triangle T_x}{5}} \\ where \triangle Tx=\triangle T₀(Ix / I₀)²

3. Ambient Temp : Tx≦105℃
L_x = L_r \times 1.5 \times 2.89 \times 2^{\frac{(105-T_x)}{10}} \times 2^{\frac{-\triangle T_x}{5}} \\ where \triangle Tx=\triangle T₀(Ix / I₀)²
  • Expected ripple life period (hrs) at maximum operating temperature allowed 在允许的最高使用温度,印加额定电压(DC)及额定纹波电流(AC) 之保证寿命
  • Expected life period (hrs) at actual operating temperature实际使用条件下的推算寿命
  • Maximum operating temperature (℃) allowed 允许的最高使用温度(℃)
  • Actual operating ambient temperature (℃),calculate as 40℃ under 40℃ 。 实际使用的环境温度(℃),低于40℃以40℃计算
  • Actual applied ripple current (mArms) at operating frequency f0 (Hz) 工作频率 f0 (Hz) 下实际印加的滤波电流(mArms)
  • Rated maximum permissible ripple current IR(mArms) x frequency multiplier (Cf) at f0 (Hz) 额定纹波电流(如目录标示值),如果在不同使用频率时,需乘以补 正系数
    ※Ripple Current calculation: no need Temperature Multiplying Factor 滤波电流计算:不需温度乘以因数
    ※For Ripple life,Ix Should be 80% equal or more of Io,if less than 80%, calculate with 80%. 纹波电流应该大于或者等于Io的80%,如果小于80%以80%计算
  • ≦5℃= Maximum temperature rise (℃) for applying I0 (mArms)印加额定纹波电流时,电容所允许的温升(小于或等于5℃)
  • The estimated life is limited to 15 years, if it exceeds 15 years, take 15 years as standard. 推算寿命以15年为上限,超过15年的以15年计之
    The actual applied ripple current shall not exceed the specification value, otherwise the formula estimation error is easy to be large and without reference value.实际使用纹波电流请勿超过规格值,否则容易导致公式估算误差大,而不具参考作用.